The M163 Vulcan Air Defense System (VADS), officially Gun, Air Defense Artillery, Self-Propelled 20-mm, M163, is a self-propelled anti-aircraft gun (SPAAG) that was primarily used by the United States Army. The M163 provides mobile, short-range air defense protection for ground units against low-flying fixed-wing aircraft and helicopters. It replaced the M42 Duster as the standard American armored light air-defense gun.^[2]

The M163 VADS uses the M168 gun, a variant of the General Dynamics 20 mm (0.79 in) M61A1 rotary cannon, the standard cannon in most U.S. combat aircraft since the 1960s. The gun is mounted on a modified M113A1 vehicle (the M741 carrier). Designed to complement the M48 Chaparral missile system, it is limited to fair-weather operations.^[3] The M163 uses a small range-only AN/VPS-2 radar and an M61 optical lead-calculating sight, and is incapable of using the radar to scan an area for targets. The system is suitable for night operations with the use of AN/PVS series night vision sights that can be mounted to the right side of the primary sight.

The gun fires at 3,000 rounds per minute in short bursts of 10, 30, 60, or 100 rounds, or it can fire in continuous fire mode at a rate of 1,000 rounds per minute.^[4] A linkless feed system is used. Its 20x102mm round gave it a low effective range of only 1,200 meters (3,900 ft), and its standard air-defense load of HEI-T rounds would self-destruct at approximately 1,800 meters (5,900 ft), a hard limit on range. The feed drum holds 1,200 rounds ready to fire, with 800 rounds stowed in reserve for the M163, later increased to 1,030 rounds stowed in reserve for the M163A1 and A2.

In US and Israeli service, the VADS has rarely been needed in its intended purpose of providing defense against aerial threats—consequently, the Vulcan gun system was in use throughout the late 1980s and early 1990s primarily as a ground support weapon. For example, VADS guns were used to support American ground assault troops in Panama in 1989 during Operation Just Cause. One Vulcan of B Battery, 2/62 ADA sank a PDF patrol boat.^[5] The last combat action the VADS participated in US service was Operation Desert Storm.

In the Israeli Air Defense Command the "Hovet" (the Israeli designation to the M163 VADS) scored 3 shoot-downs, including the first shoot-down of a jet warplane (a Syrian MiG-21 fighter jet) by the M163 VADS, during Operation Peace for Galilee in 1982.^[6] The Israel Defense Forces used the Hovet also for fire support during urban warfare in Operation Peace for Galilee (1982)^[7] and Operation Defensive Shield (2002).

In order to provide effective battlefield air defense against helicopters equipped with anti-tank missiles that could be fired accurately from ranges of several kilometers, the VADS was slated to be replaced by the M247 Sergeant York DIVADS (Divisional Air Defense System), but that system was canceled due to cost overruns, technical problems, and generally poor performance.^[8]

In 1984 the improved PIVADS (Product-Improved VADS) system was introduced, providing improvements in the ease of use and accuracy of fire, but the limitations of the 20x102 mm caliber remained. In 1988, the fourth crewmember (observer/loader) was issued a Stinger launcher and two rounds.^[9]

Eventually, the M163 was replaced in US service by the M1097 Avenger and the M6 Linebacker, an M2 Bradley with FIM-92 Stinger missiles instead of the standard TOW anti-tank guided missiles: the Stinger missile providing the necessary range to deal with helicopters with anti-tank missiles far out-ranging the 20 mm gun, as well as considerably extending the reach against fixed-wing targets. The final US Army VADS-equipped unit at Fort Riley Kansas completed turn-in of its Vulcans in 1994.

While a large number of 20x102mm rounds have been developed, not all were issued to M163 units. M246 HEI-T-SD was developed alongside the system and was the primary anti-air round, with M56 HEI being used for ground support.^[10] PIVADS units could use Mk 149 APDS rounds, which greatly increase maximum effective range due to their higher velocity and lack of a self-destruct. M940 may have been issued for use prior to withdrawal from service, though sources are unclear.

• M163
  • AVADS Automatic track VADS prototype demonstrated by General Electric for the Gun Air Defense Effectiveness Study in 1974.^[17] This prototype used a new lead-generating fire control computer paired with a helmet mounted sight. Not adopted.
  • M163A1 incorporated modifications to improve the reliability, availability, and maintainability (RAM). Type reclassified from M163E1 Improved VADS in September 1976. Newly manufactured M163A1s in 1982 used the improved M741A1 carrier, and the M741s in service were converted to M741A1 through 1985.
  • M163A2 PIVADS (1984) accuracy and workload improvements developed by Lockheed Electronics Company including a digital microprocessor, director sight and low backlash azimuth drive system. The PIVADS also used the M741A1 carrier vehicle.
• M167 towed counterpart utilizing the Gama Goat as the prime mover. After 1989 the Humvee became the prime mover.
• Machbet Israeli upgraded version equipped with 4-tube FIM-92 Stinger pod, upgraded tracking system and the ability to share information with local high-power radar.

• Korkut
• Phalanx CIWS
• SIDAM 25